[NSRCA-discussion] Li-Po Question -- SAFETY!!!!

[Rex]

That is right...  the idea of soaking the batteries in salt water for a week is to break them down into inert matter.

Then they are supposedly safe for the landfill.

 

Rex
 


From: lightfoot at sc.rr.com
To: nsrca-discussion at lists.nsrca.org
Date: Sun, 30 Aug 2009 11:22:23 -0400
Subject: Re: [NSRCA-discussion] Li-Po Question -- SAFETY!!!!





According to all the info I can find, LiPo batteries are not a problem to the environment and can be disposed of in the trash after discharge:
http://www.thunderpowerrc.com/PDF/DISPOSAL-OF-LIPO-BATTERIES.pdf
 

Jay Marshall 

-----Original Message-----
From: nsrca-discussion-bounces at lists.nsrca.org [mailto:nsrca-discussion-bounces at lists.nsrca.org] On Behalf Of Phil Spelt
Sent: Sunday, August 30, 2009 11:00 AM
To: General pattern discussion
Subject: Re: [NSRCA-discussion] Li-Po Question -- SAFETY!!!!
 
You do NOT "just throw rechargeable batteries into the trash". 

 Cadmium and lithium are heavy metals that cause harm to biological systems when ingested improperly -- i.e. from seeping into the water table from landfills.  Lithium is used in SMALL QUANTITIES to treat some kinds of mental disorders, but that is under rigid manufacturing and dosing conditions.  Lead is also a heavy metal, that is why there is an extra charge when one buys a car battery without a "trade-in".  

I was in RadShack the other day, and we happened to start talking about recycling these batteries -- they will take ANY rechargeable battery except auto batteries, including our R/C NicCads and Lipos, with no charge, and send them to a proper recycling center.  You can also usually take them to local govt. recycling centers for no charge.  Here in Oak Ridge, TN, every Wed and one Saturday per month the center is open for all kinds of hazardous items -- old PCs and TVs, paint, florescent bulbs, and on, and on.

PLEASE recycle - not because of tree-hugging, but for human and animal safety...

At 10:16 AM 8/30/2009, you wrote:


There are many ways to drain the battery down to safe levels.  I have heard the lipos are 'safe' anywhere below 2V per cell, however, I figure as long as I have something draining them, I just leave them on the load until they are basically 'dead'.
 
For anything up to 3 cells, I use an automobile tail light bulb.  Just solder 2 leads onto the bulb at the 2 contact points and clip the other ends onto the battery leads.  For a 5 cell pack, I would use 2 bulbs in series.  Put them in a safe area, clip the bulbs on and leave them for a couple days.  Check the voltage from time to time and when it gets down to about zero, just throw the battery in the trash.
 
I tried the salt water bath approach and it didn't do anything for me.  After a couple days, the voltage had declined very little so I took the light bulb approach.  Actually anything that puts a load on the batteries will work.  A large resistor, light bulb, old brushed motor, etc.
 
Don
 
In a message dated 8/30/2009 6:10:08 A.M. Pacific Daylight Time, Snaproll4 at aol.com writes:
I have a Li-Po pack(5000) that needs to be thrown away.  It does not appear to be physically damaged, but I need to know about the voltage.  How low should I discharge it and I how do I do that?  My TP charger would take it down to 3.3 volts/cell.
 
TIA.
 
Steve



 
_______________________________________________
NSRCA-discussion mailing list
NSRCA-discussion at lists.nsrca.org
http://lists.nsrca.org/mailman/listinfo/nsrca-discussion 



_______________________________________________
NSRCA-discussion mailing list
NSRCA-discussion at lists.nsrca.org
http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
--> There are only two types of aircraft -- fighters and targets.

Phil Spelt, Webmaster & Past President, Knox County Radio Control Society, Inc.
       URL: http://www.kcrctn.com
AMA--1294,  Scientific Leader Member, SPA--177
      My URL: http://mywebpages.comcast.net/~chuenkan/
      (865) 435-1476 v  (865) 604-0541 c 
-------------- next part --------------
An HTML attachment was scrubbed...
URL: <http://lists.nsrca.org/pipermail/nsrca-discussion/attachments/20090830/844a7430/attachment.html>