[NSRCA-discussion] Internal battery impedance
AtwoodDon at aol.com
AtwoodDon at aol.com
Sun Mar 16 06:42:35 AKDT 2008
Ron, did you publish the schematics for this device or was I just not paying
attention? I have some older TP5300s with over 200 flights I would love to
compare with newer cells.
thanks
Don
In a message dated 3/15/2008 9:28:21 P.M. Pacific Daylight Time,
vanputte at cox.net writes:
That's true, you do need to know the current. I should have said
that you don't need to measure it. Most people who have an
inexpensive digital multimeter have one that measures voltage, not
current. Using a precision resistor allows the determination of the
current with an inexpensive multimeter.
Ron Van Putte
On Mar 15, 2008, at 11:17 PM, Gordon Anderson wrote:
> In general you do need to know the current. The fact is measuring
> voltage across
> know resistance is measuring current. i.e. 1 Volt across a 1 ohm
> resistor is 1
> amp. So using known resistance and making voltage measurements will
> allow the
> measurement.
>
> --Gordon
>
> -----Original Message-----
> From: nsrca-discussion-bounces at lists.f3a.us
> [mailto:nsrca-discussion-bounces at lists.f3a.us] On Behalf Of Ron Van
> Putte
> Sent: Saturday, March 15, 2008 9:06 PM
> To: NSRCA Mailing List
> Subject: Re: [NSRCA-discussion] Internal battery impedance
>
> You don't need to know the current. Knowing voltage and resistance
> is enough.
> It is very simple and just as you described, It does require
> precision
> resistors.
>
> Ron Van Putte
>
>
> On Mar 15, 2008, at 10:44 PM, Lance Van Nostrand wrote:
>
>> This sounds like a way to do each cell, but don't you need the
>> current? If one were to measure the voltage across the battery and
>> the current through any resistor whose Ohmage is known then V=I *
>> (R +
>> internal resistance). or is this just too naive.
>> --Lance
>>
>> ----- Original Message -----
>> From: "Ron Van Putte" <vanputte at cox.net>
>> To: "NSRCA Mailing List" <nsrca-discussion at lists.nsrca.org>
>> Sent: Saturday, March 15, 2008 8:40 AM
>> Subject: Re: [NSRCA-discussion] Internal battery impedance
>>
>>
>>> I'd forgotten Earl had the plans.
>>>
>>> The Lipo Doc is a very simple device that is mostly a rotary switch
>>> and a couple of precision resistors. You measure voltage on the
>>> cells of a lithium polymer battery in an unloaded condition, with a
>>> 10 ohm load and a 1 ohm load. The results are put in a spreadsheet
>>> and the internal resistance of each cell is determined.
>>>
>>> Ron Van Putte
>>>
>>> On Mar 15, 2008, at 5:25 AM, Earl Haury wrote:
>>>
>>>> Lance
>>>>
>>>> I use the "LiPo Doc" built from plans I got from RVP.
>>>>
>>>> Earl
>>>> ----- Original Message -----
>>>> From: "Lance Van Nostrand" <patterndude at tx.rr.com>
>>>> To: "NSRCA Mailing List" <nsrca-discussion at lists.nsrca.org>
>>>> Sent: Friday, March 14, 2008 11:23 PM
>>>> Subject: [NSRCA-discussion] Internal battery impedance
>>>>
>>>>
>>>>> Earl,
>>>>> How do you measure the battery impedance?
>>>>> --Lance
>>>>>
>>>>> ----- Original Message -----
>>>>> From: "Earl Haury" <ejhaury at comcast.net>
>>>>> To: <chad at f3acanada.org>; "NSRCA Mailing List"
>>>>> <nsrca-discussion at lists.nsrca.org>
>>>>> Sent: Friday, March 14, 2008 10:10 AM
>>>>> Subject: Re: [NSRCA-discussion] Batteries
>>>>>
>>>>>
>>>>>> Chad, you have a point, however it's important to factor in that
>>>>>> the 1P packs are also generally higher C rating. My view when
>>>>>> considering batteries initially was that higher cell count
>>>>>> provided more failure opportunities, both as individual cell
>>>>>> failure and connections. I've disassembled a number of "failed",
>>>>>> or no longer pattern suitable packs, and measured individual cell
>>>>>> characteristics.
>>>>>>
>>>>>> Generally, the cells in a lower C pack tend demonstrate an
>>>>>> increase in impedance, resulting in lower voltage output for a
>>>>>> given current draw over their lifespan until no longer "pattern
>>>>>> viable". During this time capacity diminishes - but most cells
>>>>>> with high impedance will still retain
>>>>>> 80+% of
>>>>>> their original capacity. Even though these things generate more
>>>>>> heat than the higher C packs - they tend to handle abuse (as
>>>>>> you've found) partly because of the retained capacity and partly
>>>>>> because of "performance limiting" impedance. Post flight
>>>>>> imbalance
>>>>>> doesn't change too much as these packs age - suggesting a similar
>>>>>> "aging" of the individual cells.
>>>>>>
>>>>>> Conversely, the high C packs demonstrate very low impedance
>>>>>> initially and that appears to be retained throughout their life.
>>>>>> However, the cell capacity appears to drop pretty early and
>>>>>> continue to do so over the pack life. I've measured some of these
>>>>>> with an average capacity loss of 40% after 50 flights - that
>>>>>> means
>>>>>> a 5000 mAh pack is now a 3000 mAh pack.
>>>>>> Even
>>>>>> worse -
>>>>>> there is often a good deal of variance from cell to cell. Their
>>>>>> low impedance will provide little warning (as loss of power)
>>>>>> until
>>>>>> a cell is injured, real easy to do if you try to take 3500 mAh
>>>>>> from the now 3000 pack.
>>>>>> Often one will notice the post flight imbalance increasing as
>>>>>> these packs age and it will be greater at higher depths of
>>>>>> discharge - a sure sign some cells are getting weak. OTOH - for
>>>>>> blazing power the high C packs are the way to go - but there's a
>>>>>> price to pay in life, weight, & $$.
>>>>>>
>>>>>> These observations have led me to surmise that a pack with a high
>>>>>> enough C rating to minimize impedance losses (and accompanying
>>>>>> heat) and a low enough C rating to allow good capacity retention
>>>>>> should provide the best value for pattern. I have no idea just
>>>>>> what construction parameters / chemistry defines these
>>>>>> characteristics. I chose to try the FlightPower F3A packs because
>>>>>> they are mid-C rating and 5350 mAh capacity. So far they provide
>>>>>> good power and generate no more heat than the high C packs I've
>>>>>> used. I expect that the extra capacity (above 5000) offers a
>>>>>> little buffer if there is a capacity decline over their life. I
>>>>>> see little balancer activity with these packs regardless of depth
>>>>>> of discharge (say 3000 mAh vs 4000 +) so far, time will tell -
>>>>>> we're all still learning.
>>>>>>
>>>>>> Earl
>>>>>>
>>>>>> Team FlightPower
>>>>>>
>>>>>>
>>>>>> ----- Original Message -----
>>>>>> From: "Chad Northeast" <chad at f3acanada.org>
>>>>>> To: "NSRCA Mailing List" <nsrca-discussion at lists.nsrca.org>
>>>>>> Sent: Friday, March 14, 2008 8:22 AM
>>>>>> Subject: Re: [NSRCA-discussion] Batteries
>>>>>>
>>>>>>
>>>>>>> I think a huge part of the 5300 Prolites ability to deliver
>>>>>>> under
>>>>>>> extreme abuse (I should know! :) ) is in large part due to a 4p
>>>>>>> config rather than 1p as in the current packs. In a 1p when
>>>>>>> that
>>>>>>> cell gets weak its over, in a 4p when a cell gets weak the other
>>>>>>> 3 in the 4p can help it along for quite a while before they all
>>>>>>> get weak.
>>>>>>>
>>>>>>> I am really convinced that a move to 1p config packs has brought
>>>>>>> with it lower useful cycle life. I feel you need to be a lot
>>>>>>> more cautious with the 1p packs than the 4p's, or they will not
>>>>>>> last you very long :)
>>>>>>>
>>>>>>> Chad
>>>>>>>
>>>>>>> mike mueller wrote:
>>>>>>>> Chris Moon and I have bought the new TrueRC 5000 packs. He has
>>>>>>>> been testing them for the last 2 months. They seem as strong if
>>>>>>>> not stronger than his FP 5350 pack. The cost is only $110 a 5S
>>>>>>>> pack. I've bought 4 packs and I'm hoping that they are as good
>>>>>>>> as initial testing has shown. I also have 2 brand new TP V2
>>>>>>>> Extreme 10S 5000 packs. All the packs at the 10S configuration
>>>>>>>> weigh in around 42oz's with all the connectors.
>>>>>>>> The True RC packs have a lower C rating but this may be a good
>>>>>>>> thing.
>>>>>>>> The higher C ratings seem to come at the cost of lower pack
>>>>>>>> life. Look at the TP Pro lite's many have exceeded the 200
>>>>>>>> cycle
>>>>>>>> barrier and still have a decent pack. The TP Extreme's V1's
>>>>>>>> were
>>>>>>>> dying in 50 flights and I have yet to see much better than a
>>>>>>>> hundred flights from the FP's. From my observation the older TP
>>>>>>>> Prolites deliver plenty of power for our setups. So I think the
>>>>>>>> TrueRC offerings are going to do the trick. Dan from True is
>>>>>>>> claiming over 200 cycles on them. I hope that I can get 100. At
>>>>>>>> the $'s he's getting it will be a huge bargain.
>>>>>>>> Mike Mueller
>>>>>>>>
>>>>>>>> The link is www.flightpowerusa.com <http://
>>>>>>>> www.flightpowerusa.com/>
>>>>>>>>
>>>>>>>> I need to buy some packs myself. Anybody know if they will
>>>>>>>> be at
>>>>>>>> Toledo?
>>>>>>>>
>>>>>>>> Bob Kane
>>>>>>>> getterflash at yahoo.com
>>>>>>>>
>>>>>>>>
>>>>>>>> ----- Original Message ----
>>>>>>>> From: Verne Koester <verne at twmi.rr.com>
>>>>>>>> To: NSRCA Mailing List <nsrca-discussion at lists.nsrca.org>
>>>>>>>> Sent: Thursday, March 13, 2008 6:58:32 PM
>>>>>>>> Subject: Re: [NSRCA-discussion] Batteries
>>>>>>>>
>>>>>>>> Hi George,
>>>>>>>> I'm in the same situation and have decided to go with the
>>>>>>>> FlightPower
>>>>>>>> 5350's. Even when the 5300's were fresh, I occasionally
>>>>>>>> felt
>>>>>>>> like
>>>>>>>> I could
>>>>>>>> use a little more punch, particularly on humid or windy
>>>>>>>> days. I've
>>>>>>>> competed
>>>>>>>> with a number of guys that had both the TP 5300's and FP
>>>>>>>> 5350's
>>>>>>>> who would
>>>>>>>> switch to the 5350's when they needed the extra power. My
>>>>>>>> plan is
>>>>>>>> to use the
>>>>>>>> FP 5350's and change props for different conditions.
>>>>>>>> Nothing is
>>>>>>>> free however
>>>>>>>> and you'll pick up 2 ounces in the process. I considered
>>>>>>>> the
>>>>>>>> 5000
>>>>>>>> mah 10S
>>>>>>>> packs from both TP and FP but can't afford to gain 4 ounces
>>>>>>>> in
>>>>>>>> either of my
>>>>>>>> existing planes. The FP 5350's are the best solution for my
>>>>>>>> situation. Mine
>>>>>>>> just arrived this week and won't be flown until the snow
>>>>>>>> melts so my
>>>>>>>> recommendations come from observations rather than
>>>>>>>> experience at
>>>>>>>> this point.
>>>>>>>> I bought mine directly from FlightPower
>>>>>>>> http://www.flightpower.com <http://www.flightpower.com/
>>>>>>>>> . Hope
>>>>>>>> this helps.
>>>>>>>>
>>>>>>>> Verne Koester
>>>>>>>>
>>>>>>>>
>>>>>>>> ----- Original Message -----
>>>>>>>> From: <glmiller3 at suddenlink.net
>>>>>>>> <mailto:glmiller3 at suddenlink.net>>
>>>>>>>> To: "NSRCA List" <nsrca-discussion at lists.nsrca.org
>>>>>>>> <mailto:nsrca-discussion at lists.nsrca.org>>
>>>>>>>> Sent: Thursday, March 13, 2008 12:26 PM
>>>>>>>> Subject: [NSRCA-discussion] Batteries
>>>>>>>>
>>>>>>>>
>>>>>>>>> Hi All,
>>>>>>>>>
>>>>>>>>> I've been flying with Thunder Power Prolite 5300 packs for a
>>>>>>>> while now and
>>>>>>>>> they are getting very tired. As they poop out, I'm trying to
>>>>>>>> decide what
>>>>>>>>> to replace them with. From what I've seen, the Flightpower
>>>>>>>> "FAI" packs
>>>>>>>>> are probably what I'll go with, but if anyone has any other
>>>>>>>> suggestions,
>>>>>>>>> please sing out. Also, any suggestions as to a source
>>>>>>>>> would be
>>>>>>>>> appreciated.
>>>>>>>>>
>>>>>>>>> TIA,
>>>>>>>>>
>>>>>>>>> George
>>>>>>>>> _______________________________________________
>>>>>>>>> NSRCA-discussion mailing list
>>>>>>>>> NSRCA-discussion at lists.nsrca.org
>>>>>>>> <mailto:NSRCA-discussion at lists.nsrca.org>
>>>>>>>>> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>>>>>>>>>
>>>>>>>>
>>>>>>>>
>>>>>>>> _______________________________________________
>>>>>>>> NSRCA-discussion mailing list
>>>>>>>> NSRCA-discussion at lists.nsrca.org
>>>>>>>> <mailto:NSRCA-discussion at lists.nsrca.org>
>>>>>>>> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>>>>>>>>
>>>>>>>>
>>>>>>>>
>>>>>>>> ---------------------------------------------------------------
>>>>>>>> -
>>>>>>>> --
>>>>>>>> ------
>>>>>>>> Looking for last minute shopping deals? Find them fast with
>>>>>>>> Yahoo!
>>>>>>>> Search.
>>>>>>>>
>>>>>>>> <http://us.rd.yahoo.com/evt=51734/*http://
>>>>>>>> tools.search.yahoo.com/newsearch/category.php?
>>>>>>>> category=shopping>_____________________________________________
>>>>>>>> _
>>>>>>>> _
>>>>>>>> NSRCA-discussion mailing list
>>>>>>>> NSRCA-discussion at lists.nsrca.org
>>>>>>>> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>>>>>>>>
>>>>>>>>
>>>>>>>> ---------------------------------------------------------------
>>>>>>>> -
>>>>>>>> --
>>>>>>>> ------
>>>>>>>> Never miss a thing. Make Yahoo your homepage.
>>>>>>>> <http://us.rd.yahoo.com/evt=51438/*http://www.yahoo.com/r/hs>
>>>>>>>> ---------------------------------------------------------------
>>>>>>>> -
>>>>>>>> --
>>>>>>>> ------
>>>>>>>>
>>>>>>>> _______________________________________________
>>>>>>>> NSRCA-discussion mailing list
>>>>>>>> NSRCA-discussion at lists.nsrca.org
>>>>>>>> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>>>>>>> _______________________________________________
>>>>>>> NSRCA-discussion mailing list
>>>>>>> NSRCA-discussion at lists.nsrca.org
>>>>>>> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>>>>>>
>>>>>> _______________________________________________
>>>>>> NSRCA-discussion mailing list
>>>>>> NSRCA-discussion at lists.nsrca.org
>>>>>> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>>>>>
>>>>> _______________________________________________
>>>>> NSRCA-discussion mailing list
>>>>> NSRCA-discussion at lists.nsrca.org
>>>>> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>>>>
>>>> _______________________________________________
>>>> NSRCA-discussion mailing list
>>>> NSRCA-discussion at lists.nsrca.org
>>>> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>>>
>>> _______________________________________________
>>> NSRCA-discussion mailing list
>>> NSRCA-discussion at lists.nsrca.org
>>> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>>
>>
>> _______________________________________________
>> NSRCA-discussion mailing list
>> NSRCA-discussion at lists.nsrca.org
>> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>
> _______________________________________________
> NSRCA-discussion mailing list
> NSRCA-discussion at lists.nsrca.org
> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
>
>
>
> _______________________________________________
> NSRCA-discussion mailing list
> NSRCA-discussion at lists.nsrca.org
> http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
_______________________________________________
NSRCA-discussion mailing list
NSRCA-discussion at lists.nsrca.org
http://lists.nsrca.org/mailman/listinfo/nsrca-discussion
**************It's Tax Time! Get tips, forms, and advice on AOL Money &
Finance. (http://money.aol.com/tax?NCID=aolprf00030000000001)
-------------- next part --------------
An HTML attachment was scrubbed...
URL: http://lists.nsrca.org/pipermail/nsrca-discussion/attachments/20080316/da0d92e2/attachment-0001.html
More information about the NSRCA-discussion
mailing list